When i turned the unit on it begin leaking into the camper in the area of the filter.
Rv roof mount air unit leaks int coach.
This can be a result of debris or dirty on evaporator coils or due to blocking of the drain holes due to dirt or due to purposely done sealing.
There are no drain lines for the ac unit on the roof of the rv.
If it is leaking inside you most likely have a clogged outlet which can be easily opened with a stiff wire probed in the drain outlet.
Check to make sure your model does not have a condensation hose that may be plugged.
Also you need to check the torque of the fastening bolts.
To check for this situation again disconnect yourself from power and carefully ascend to the roof.
Have duo therm rv ac on roof of my camper.
Some people will actually leave the rig slightly higher to the passenger side so the water runs to the other side.
Roof mounted air conditioners are very heavy units.
If the leak is both while raining and while running and the gasket is still thick enough and tight odds are there is some roof deterioration underneath the air conditioner as long as the roof isn t sagging causing water to puddle up around the air conditioner which can be checked by pulling a string across the roof from side to side.
One of the most common causes of the water leaking from air conditioner in rv is drain pan not able to drain the water properly.
However if the drain hole s get clogged with dirt leaves etc the water may roll into your coach even if the a c roof gasket is tight.
It is quite common to find the roof area around the air conditioner sunken or sagging especially on those rvs with soft roof construction.
Next inside the rv install the bolts that will hold the ceiling part of the air conditioner in place.
It s best not to walk on an rv roof rather use boards to distribute your weight.
Look for screws or other hardware the hold the outer shroud cover on your a c unit.
As mentioned above the drain pan has a small hole in it allowing the water to drip out.
The condensation drips down into a pan which has an outlet on the side of the base pan that lets the water run onto the roof.
Condensation from the a c unit has been a long time battle with rv owners.
Which ideally should drain the water from the evaporator coil on the roof instead of inside of the rv.
There was a co read more.
What happens is water can start to collect.
Finally mount and secure the ceiling portion.
Your roof ac unit is mounted with a gasket between the unit an the roof typically with 4 spring loaded fasteners that should be checked for specific torque or tightness every year.
Model xxxxx ser xxxxx purchased with camper in 2002.
You should be able to find the torque specs in the roof ac owner s manual however a good hand tightening should be good.
Mount the roof part of the air conditioner over the hole.
Then screw the unit in with the mounting bolts at the locations you ve marked.
They are subject to all the vibration wind and the elements that occur during your ownership of the rv.
